1. Throttle body installation: (1) Clean the installation face of the intake manifold, install the throttle body assemblyto the intake manifold interface, and tighten the screws；(2)Install water pipes and other hoses；(3)Plug in the wiring plug of the throttle body；(4)Connect the air intake hose and tighten the locking ring.2. Matched New Throttle Body Assembly For 2006-2008 Audi A4 A6 3.2L 2.7L 079133062C
1. Throttle body installation:
(1) Clean the installation face of the intake manifold, install the throttle body assemblyto the intake manifold interface, and tighten the screws；
(2)Install water pipes and other hoses；
(3)Plug in the wiring plug of the throttle body；
(4)Connect the air intake hose and tighten the locking ring.
2. Matched
- High idle or unsteady idle will generally occur after the throttlebody is replaced,Or an engine failure light;
- This is because the car ECU stores the original throttle body parameters, and the newly installed throttle bpdy parameters are inconsistent with
- the original;
- At this point, the throttle body needs to be matched by computer. The matching process is to erase the original memory of THE ECU and start the self-learning process again.
After installation, a dedicated
computer must be used to
connectthe CAR ECU to
clear the fault code and
restorethe initial state.
Note:
1. Ensure that the cable plug
of the throttle body is inserted;
2. The fault code is cleared;
3. Appropriate tightness of
throttle cable. (mechanical
and semi- electronic);
Remind:Install by trained
professionals.
- In cases where there is no matching computer or the computer cannot match, the following manual method can be used to match.
- Method 1: The negative electrode of battery line can be disconnected to eliminate the memory function of ECU, and it can be installed after 1 minute.
- Method 2:Turn off the ignition switch and remove the EFI and ETCS fuses in the fuse box in the engine compartment.
The above two methods are to eliminate the memory of THE ECU. If the idle speed is still high at this time, the ECU can return to normal speed through 1 to 2 days of self-learning.
3.Common throttle body faults and causes
(1)Throttle body cannot open: accelerator pedal position sensor, throttle body motor, ECU,
Power supply and circuit, throttle body internal stuck;
(2)Insufficient throttle body opening: throttlebodystuck, accelerator pedal position sensor, throttle body position sensor, safety mode;
(3)Idle low or high：throttlebodystuck, excessive carbon accumulation in throttle body and inlet, leakage in intake pipe and various valve connections, initialization or idle learning not set;
4. Quality problems and phenomena of throttle body itself
(1) Incorrect intake volume of throttle body:
- (Electronic and semi-electronic) throttle body Butterfly valvestuck;
- ?Judgment method:Pull theButterfly valveto fully open and fully closed by hand and then slowly put it back to check whether the throttle valve piece returns to the correct initial position smoothly;
- Excessive carbon accumulation in inlet.
Full open state Fully closed state Too muchcarbonstate
(2) Throttle body position sensor output signal error:
Voltage division ratio
New TPS1 TPS2
At UMA(lower mechanical stop) 10%±4% 90%±4%
At OMA(upper mechanical stop) 93%±4% 7%±4%
After lifetime
At UMA(lower mechanical stop) 10%±5% 90%±5%
At OMA(upper mechanical stop) 93%±5% 7%±5%
The signal from the sender is read out in percent on theassociated measured valve The power line is not connected properly:
- Bad contact of throttle plug;
- The built-in circuit is broken or short-circuited.
5.Impact of other related accessories
In addition to the product quality problems of the throttle body itself, the failure of other related accessories will also affect the normal use or failure of the throttle body.
Fitment Chart
2006-2008 Audi A4 Base Sedan 3.2L V6
2005-2008 Audi A4 Quattro Avant Wagon 3.2L V6
2007-2009 Audi A4 Quattro Base Sedan 3.2L V6
2007-2009 Audi A4 Quattro Cabriolet Convertible 3.2L V6
2005-2009 Audi A6 Base Sedan 3.2L V6
2000-2004 Audi A6 Quattro Base Sedan 2.7L V6
2005-2008 Audi A6 Quattro Base Sedan 3.2L V6
2006-2008 Audi A6 Quattro Avant Wagon 3.2L V6
2001-2004 Audi Allroad Quattro Base Wagon 2.7T V6
2005 Audi Allroad Quattro Base Wagon 2.7T V6 (thru VIN 026300)
2000-2002 Audi S4 Base Sedan 2.7L V6 Turbocharged
2001-2002 Audi S4 Avant Wagon 2.7L V6 Turbocharged
2007-2011 Audi S6 Base Sedan 5.2L V10
2007-2009 Audi S8 Base Sedan 5.2L V10
2009-2014 Audi R8 Base Coupe 4.2L V8
2011-2014 Audi R8 Spyder Convertible 4.2L V8
Item SpecificsBrand :Topcn-autopartsManufacturer Part Number :TA1031090418PMounting Hardware Included :NoBore Diameter :68mmManufacturer Warranty :1 YearCustom Bundle :NoFitment Type :Direct ReplacementMaterial :AluminumColor :MetalWeight :3 LBOE Spec or Performance/Custom :Performance/CustomItems Included :1 Fuel Injection Throttle BodyPackage Quantity :1 Throttle BodyPackaging Type :BoxInterchange Part Number :0280750003OE/OEM Part Number :XZNJG00667Superseded Part Number :078133062C,078133062Type :ElectricalPlacement on Vehicle :Front
Shipping
WARNING: Cancer and Reproductive Harm - www.P65Warnings.ca.gov.
1. Package handling takes about 2 business days at our warehouse, so please make sure entering correct payment and shipping information before checking out. Once your payment is completed, we are not going to accept any more changes to your order.
2.All domestic orders will be shipped via USPS, UPS or Fedex from our US warehouse and usually arrives to your door in about 2-5 business days.
3.Local pick up is not available.
4.Orders to the rest of world may be shipped out from our warehouse in HongKong.
5.International Buyers C Please Note:
a. Import duties, taxes and charges are not included in the item price or shipping charges. These charges are the buyers responsibility.
b. Please check with your country customs office to determine what these additional costs will be prior to offerding/buying.
Payment
We only accept payment through PayPal. You can open a Paypal account at www.paypal.com.
Returns
1.All of our brand new items come with a 60-Days money-back guarantee.
2.We define the item as defective only if it doesn't function as described, It is the buyer's responsibility to understand the item description before offerding.
3.We will replace the defective items, provided that they are in stock within the warranty period posted with the listing and the buyer return the original item and pay for the S&H cost for the replacement.
4.We will refund the purchase price if the replacement is not available or buyer prefers a refund and send the original item back at his/her own cost.
5.Shipping& handling cost are not refundable.
6.Man-made damage by abuse or wrong operation is not covered by this warranty.
7.No product liability insurance is assumed.
8.Refunds will be credited within 5 to 7 business days of receiving the return. When we've received and processed the return, we will refund the applicable amount minus any Recovery Fees (See Details Below) for the amount you paid for the item(s), plus any applicable sales tax.
Customer Services
Q: How do I pay for my purchase?
A: MY store accepts PayPal.
Q: When will the item be shipped out?
A: This item will be shipped with 2 business day once payment completed.
Q: Where is my tracking number?
A: Please log on your account, click "my "-->"my summary", or open your email box and find the shipping notification email.
Q: How do I return an item?
A: My tore accepts returns. Items must be returned within 60 days. Refunds will be given as money back. Please contact our customer service before you return an item.
response
1. We will leave positive response once we get your payment.
2. If you are dissatisfied for any reason, please do not be quick to leave negative/neutral response. We will work hard to make sure EVERY CUSTOMER 100% SATISFIED and resolve any problem for you and always leave positive response to all our customers.
3. If you are satisfied with the product you received, please leave us positive response and 5 scores DSR.
DESCRIPTIONPAYMENTSHIPPINGRETURN POLICYCONTACT US Shop CategoryStore Home Ignition Coils complete struts Radiator Support Wheel Hub Bearing Wheel Adaptor Oxygen Sensor Towing mirrors Fuel pump assembly Lift supports Starter Key or key case struts floor mats wheel lug nuts Cylinder Piston Gasket Kit Cylinder Head Gasket Sets CV Axle Door handle Radiator fastener UTV & ATV Brake System Parts▷Brake Pads♢Sintered Brake Pads♢Kevlar Carbon Brake Pads◈Brake Shoes Regulator Rectifier blower motor fan blower motor resistor suspension kit◈suspension kits◈suspension cj◈suspension gxy◈suspension fu AC Compressor Brake system◈Brake Rotors◈Brake Pads◈Brake Rotors and Pads◈Brake Pad Sensor◈Brake Drum◈Brake Shoes◈Brake Calipers◈Brake Calipers & pads◈Brake Calipers & Rotors & pads Car Seat Cover Air Suspensions Nerf Bars & Running Boards Window Switch Mass Air Flow Sensor-MAF Window Regulator Side Fender marker Alternator Leveling Lift Kit Car Cover Fuel Injector Coilover Car Tools License Plate Frame Windshield Wiper Motor Thermostat Housing Radiator Coolant Tank Fuel Tank Pipe Valve Cover Door Lock Actuator Power Steering Pump Variable Timing Solenoid (VVT) Electric Water Pump Timing Chain Kits Timing Belt Kits Water Pumps Oil Pump Strut Tie Bar Tire Pressure Sensor Throttle Body Harmonic Balancer Oil Pan Motorcycle Carburetor & Parts Urea Pump Cooling Fan Cooling Fan Clutch Oil Cooler Hydraulic Lifter&Roller Lifter Suspension+Strut+Bearing HVAC ATV Rear Wheel Axle Parking sensor Car Antenna ABS Wheel Speed Sensor PTO Clutch Spoilers & Wings Tensioners Purge Valve Knock Sensor Turbocharger Crankshaft Position Sensor Camshaft Position Sensor MAP Sensor Oil Pressure Sensor Throttle Position Sensor Stator idle air control valve Transfer Case Shift Motor Secondary Air Injection Pump Running Board Motor Consoles & Parts Roof rack Bumper Tire Pressure Gauge Steering Rack Air Diesel Heater Engine Mount Glow Plug Air Cleaner Filter Box Cylinder Piston Kit Pressure Tester Gauge Jack Stands Wheel Lug Sun Visor Window Visor trim tilt motor ATV Brake Caliper Oil Catch Can Tank Crankcase Vent Valve Horns Steering U-Joint Fuel Cell Tank Height Level Sensor Temperature Sensor Driveshaft Air Ride Suspension Valves Calipers & Rotors◈Calipers & Rotors Pads Radiator Hose Ballast module Rubber Seal Strip Dipstick Removal Open Tools Camshaft & Crankshaft ATV Brake Master Cylinder Rocker Arm Battery Switch Oil Fuel Hose Line brake Hose Line LED headlight Assembly Wheel Hub Bearing Knuckle headlight motorcycle Foot Rest Pedal O Ring water Pump Impeller Strut Mount Splash Guards & Mud Flaps Heater Cores Evaporators vehicle speed sensor RV Water Pump Fuel Pressure Regulator Light Bar Mount Bracket Sensor-8 CV axle+Brake Pads/Rotors universal spacer Steering Shaft transmission filter Steering Wheel Steering Wheel Hub Steering Gear Box snorkel air intake CDI BOX Proportioning Valve Spindle Window Glass Hinge Other Golf Cart Parts Intercoolers Crankshaft Pulley Steering Knuckle 4 pcs wheel hub bearing Fender Flares jumper cable Tonneau Cover Bug Shield Front Bumper Lip dash cover primary drive clutch golf car seat crevice box AC Compressor Control Valve+A carburetor intake mainfold Fuel Valve& Petcocks Garden Water Pump air vent Ignition Wires Lower Kits & Parts Cargo Cover Leaf Springs Shift Knobs & Boots Hub Caps ATV Ignition Switch fog lights winch Jeep Wrangler Headlights Pivot Brake Clutch Lever Power Brake Booster leveling kit + struts shocks Wheel Rim Lights◈Side/Cab Marker Lights◈Instrument Panel Lights◈Third Brake Lights◈Interior Lights◈Exterior Lights◈Led Headlights◈Special Model Lights Handlebar Riser flywheel Air Dryer steering knuckle-7 Bed Step OtherHot Item Upstream & Downstream Oxygen O2 02 Sensor For 2001-2005 Honda Civic 1.7L D17A7 USD 23.81 2 For Dodge Challenger 2008-2014 Keyless Entry Remote Control Car Key Fob USD 18.35 2x Front Hood Lift Supports Shocks Struts For Dodge Ram 1500 2500 3500 4500 5500 USD 17.74 2x Front Hood Gas Lift Supports Struts Shocks Springs For Dodge Ram 02-10 4364 USD 17.69 Throttle Body for Dodge Avenger Journey Caliber Jeep Patriot Compass 2.4L 2.0L USD 46.99 New List Item For Honda Pilot 2003-2008 Aluminum Luggage Carrier Top Roof Rack Cross Bars USD 70.40 2pcs for 1996-2000 Toyota 4Runner 2.7L Upstream Downstream Oxygen Sensor O2 02 USD 25.99 Brand New for 2002-2004 Volkswagen Passat 4.0L W8 02 O2 Oxygen Sensor Upstream USD 34.99 Roof Top Rack For KIA Telluride 2019 2020 Blk CrossBar Carrier luggage Aluminum USD 77.86 Black Roof Rack For Toyota RAV4 XA30 2006- 2012 Cover Rail End Shell Replacement USD 18.09 New Throttle Body Assembly For 2006-2008 Audi A4 A6 3.2L 2.7L 079133062C
1. Throttle body installation:
(1) Clean the installation face of the intake manifold, install the throttle body assemblyto the intake manifold interface, and tighten the screws；
(2)Install water pipes and other hoses；
(3)Plug in the wiring plug of the throttle body；
(4)Connect the air intake hose and tighten the locking ring.
2. Matched
- High idle or unsteady idle will generally occur after the throttlebody is replaced,Or an engine failure light;
- This is because the car ECU stores the original throttle body parameters, and the newly installed throttle bpdy parameters are inconsistent with
- the original;
- At this point, the throttle body needs to be matched by computer. The matching process is to erase the original memory of THE ECU and start the self-learning process again.
After installation, a dedicated
computer must be used to
connectthe CAR ECU to
clear the fault code and
restorethe initial state.
Note:
1. Ensure that the cable plug
of the throttle body is inserted;
2. The fault code is cleared;
3. Appropriate tightness of
throttle cable. (mechanical
and semi- electronic);
Remind:Install by trained
professionals.
- In cases where there is no matching computer or the computer cannot match, the following manual method can be used to match.
- Method 1: The negative electrode of battery line can be disconnected to eliminate the memory function of ECU, and it can be installed after 1 minute.
- Method 2:Turn off the ignition switch and remove the EFI and ETCS fuses in the fuse box in the engine compartment.
The above two methods are to eliminate the memory of THE ECU. If the idle speed is still high at this time, the ECU can return to normal speed through 1 to 2 days of self-learning.
3.Common throttle body faults and causes
(1)Throttle body cannot open: accelerator pedal position sensor, throttle body motor, ECU,
Power supply and circuit, throttle body internal stuck;
(2)Insufficient throttle body opening: throttlebodystuck, accelerator pedal position sensor, throttle body position sensor, safety mode;
(3)Idle low or high：throttlebodystuck, excessive carbon accumulation in throttle body and inlet, leakage in intake pipe and various valve connections, initialization or idle learning not set;
4. Quality problems and phenomena of throttle body itself
(1) Incorrect intake volume of throttle body:
- (Electronic and semi-electronic) throttle body Butterfly valvestuck;
- ?Judgment method:Pull theButterfly valveto fully open and fully closed by hand and then slowly put it back to check whether the throttle valve piece returns to the correct initial position smoothly;
- Excessive carbon accumulation in inlet.
Full open state Fully closed state Too muchcarbonstate
(2) Throttle body position sensor output signal error:
Voltage division ratio
New TPS1 TPS2
At UMA(lower mechanical stop) 10%±4% 90%±4%
At OMA(upper mechanical stop) 93%±4% 7%±4%
After lifetime
At UMA(lower mechanical stop) 10%±5% 90%±5%
At OMA(upper mechanical stop) 93%±5% 7%±5%
The signal from the sender is read out in percent on theassociated measured valve The power line is not connected properly:
- Bad contact of throttle plug;
- The built-in circuit is broken or short-circuited.
5.Impact of other related accessories
In addition to the product quality problems of the throttle body itself, the failure of other related accessories will also affect the normal use or failure of the throttle body.
Fitment Chart
2006-2008 Audi A4 Base Sedan 3.2L V6
2005-2008 Audi A4 Quattro Avant Wagon 3.2L V6
2007-2009 Audi A4 Quattro Base Sedan 3.2L V6
2007-2009 Audi A4 Quattro Cabriolet Convertible 3.2L V6
2005-2009 Audi A6 Base Sedan 3.2L V6
2000-2004 Audi A6 Quattro Base Sedan 2.7L V6
2005-2008 Audi A6 Quattro Base Sedan 3.2L V6
2006-2008 Audi A6 Quattro Avant Wagon 3.2L V6
2001-2004 Audi Allroad Quattro Base Wagon 2.7T V6
2005 Audi Allroad Quattro Base Wagon 2.7T V6 (thru VIN 026300)
2000-2002 Audi S4 Base Sedan 2.7L V6 Turbocharged
2001-2002 Audi S4 Avant Wagon 2.7L V6 Turbocharged
2007-2011 Audi S6 Base Sedan 5.2L V10
2007-2009 Audi S8 Base Sedan 5.2L V10
2009-2014 Audi R8 Base Coupe 4.2L V8
2011-2014 Audi R8 Spyder Convertible 4.2L V8
Item SpecificsBrand :Topcn-autopartsManufacturer Part Number :TA1031090418PMounting Hardware Included :NoBore Diameter :68mmManufacturer Warranty :1 YearCustom Bundle :NoFitment Type :Direct ReplacementMaterial :AluminumColor :MetalWeight :3 LBOE Spec or Performance/Custom :Performance/CustomItems Included :1 Fuel Injection Throttle BodyPackage Quantity :1 Throttle BodyPackaging Type :BoxInterchange Part Number :0280750003OE/OEM Part Number :XZNJG00667Superseded Part Number :078133062C,078133062Type :ElectricalPlacement on Vehicle :Front
ShippingPaymentReturnsCustomer Servicesresponse
WARNING: Cancer and Reproductive Harm - www.P65Warnings.ca.gov.
1. Package handling takes about 2 business days at our warehouse, so please make sure entering correct payment and shipping information before checking out. Once your payment is completed, we are not going to accept any more changes to your order.
2.All domestic orders will be shipped via USPS, UPS or Fedex from our US warehouse and usually arrives to your door in about 2-5 business days.
3.Local pick up is not available.
4.Orders to the rest of world may be shipped out from our warehouse in HongKong.
5.International Buyers C Please Note:
a. Import duties, taxes and charges are not included in the item price or shipping charges. These charges are the buyers responsibility.
b. Please check with your country customs office to determine what these additional costs will be prior to offerding/buying.
We only accept payment through PayPal. You can open a Paypal account at www.paypal.com.
1.All of our brand new items come with a 60-Days money-back guarantee.
2.We define the item as defective only if it doesn't function as described, It is the buyer's responsibility to understand the item description before offerding.
3.We will replace the defective items, provided that they are in stock within the warranty period posted with the listing and the buyer return the original item and pay for the S&H cost for the replacement.
4.We will refund the purchase price if the replacement is not available or buyer prefers a refund and send the original item back at his/her own cost.
5.Shipping& handling cost are not refundable.
6.Man-made damage by abuse or wrong operation is not covered by this warranty.
7.No product liability insurance is assumed.
8.Refunds will be credited within 5 to 7 business days of receiving the return. When we've received and processed the return, we will refund the applicable amount minus any Recovery Fees (See Details Below) for the amount you paid for the item(s), plus any applicable sales tax.
Q: How do I pay for my purchase?
A: MY store accepts PayPal.
Q: When will the item be shipped out?
A: This item will be shipped with 2 business day once payment completed.
Q: Where is my tracking number?
A: Please log on your account, click "my "-->"my summary", or open your email box and find the shipping notification email.
Q: How do I return an item?
A: My tore accepts returns. Items must be returned within 60 days. Refunds will be given as money back. Please contact our customer service before you return an item.
1. We will leave positive response once we get your payment.
2. If you are dissatisfied for any reason, please do not be quick to leave negative/neutral response. We will work hard to make sure EVERY CUSTOMER 100% SATISFIED and resolve any problem for you and always leave positive response to all our customers.
3. If you are satisfied with the product you received, please leave us positive response and 5 scores DSR.
Copyright of Topcn-autoparts. All rights reserved.
